What are the common faults of garbage collector in operation?

Electric garbage trucks will inevitably have some trouble, the occurrence of trouble problems will be more serious harm to the efficiency of the work, therefore, to find out the key reasons for the failure of electric garbage trucks to carry out maintenance immediately is the importance of repairing mechanical energy, below Haixiang environmental protection technology to tell you about the garbage trucks in the operation of the common faults.

1, brake pedal continuous electricity

There are two key reasons for the continuous power of the brake pedal of the electric garbage collector. The first is that the brake pedal turns off the power supply and the power switch is damaged or the contact is bad. For this kind of problem, if the contact is bad, it can be repaired, and if it is damaged, it can be selected and replaced. The next is the control board burned, only choose to replace a new control board, prompting it to be fixed when replacing the control board, as far as possible with the "ground non-slip" screw tighten the ground non-slip, to prevent real-time road conditions are not good shaking lead to the control board original welding short circuit fault and damage.

2, the rechargeable battery is full as soon as it is charged, and it is used up

The key reason is that the electric garbage truck rechargeable battery vulcanization failure, the vulcanized rechargeable battery can be repaired with a repair instrument, the selection of fuzzy computer control basic theory, according to the measurement of battery status, in the battery charging of the other continuous transmission of positive and negative frequency conversion particle waves, with 10 to 20 hours of time, remove the hard lead sulfate after the crystal in the rechargeable battery.

3, the motor has abnormal sound

If the electric garbage truck motor abnormal sound, there are three key reasons, one is Hall components burned, resulting in phase break, for this kind of problem, you can choose to change Hall. The second is the motor physics fault, such faults only need to be checked out and repaired. Three is rolling bearing rust, just wipe grease.

4. Suddenly turn off the power while driving

The key reasons are three, one is the electric garbage truck rechargeable battery switch power supply output power plug and power socket contact phenomenon, re-plug on the line, the second is the fault of the transmission handle, repair the transmission handle. The third is the brake pedal to turn off the power problem, you can try to brake a few cars, and then everything runs normally.